苏州西门子伺服电机维修故障：磁铁爆钢、磁铁脱落、卡死转不动、编码器磨损、码盘/玻璃盘磨损破裂、电机发热发烫、电机进水、电机运转异常、高速运转响声、噪音大，刹车失灵、刹车片磨损、低速正常高速偏差、高速正常低速偏差、启动报警、启动跳闸、过载、过压、过流、不能启动、启动无力、运行抖动、失磁、跑位、走偏差、输出不平衡、编码器报警、编码器损坏、位置不准、一通电就报警、一通电就跳闸、驱动器伺服器报警代码、烧线圈绕组、航空插头损坏、原点位置不对，编码器调试/调零位、更换轴承、轴承槽磨损、转子断裂，轴断裂、齿轮槽磨损等。
西门子伺服电机的基本知识：西门子伺服电机包括：1PH/1FT/1FK/主轴电机、传动电机、主轴电机冷却风机。
1、 编码器报警故障：更换编码器（1381/1387/1325）测速发电机/旋转变压器/增量/值等均可更换对位，基本华北地区值编码器均为我公司对位置测试维修；
2、 绕组故障：开路或短路及扫堂对绕组造成的损坏；均为所有绕组漆包线均为***，线径、线长、线重均与原电机参数相当，手工打绕组，低温烘干，确保对绕组做到与原电机要求参数一致；达到更高使用标准；
3、接头电缆座及座内连接针及密封圈等：各系列伺服电机电缆座我公司均备有大量***，均可在***时间修复；
4、 抱闸故障：所有抱闸损坏均采用更换式维修，不提倡维修抱闸因维修的抱闸用不住；
5、 电机前后法兰故障：因受外力因素导至电机前后法兰破碎均可更换，我公司常用电机均有备件，特种电机法兰均可采用内部置换进行修复；
6、 伺服电机转子、定子故障：扫堂导或外力导致转子、定子变型，均可更换修复；
7、 主轴风机故障：西门子主轴伺服电机散热风机大部份为其它品牌，我公司已经成功修复3400多套风机；
伺服电机故障维修覆盖、绕组、轴承、编码器、转子、定子、法兰、接头座等均可修复；
1FK电机系列型号
1FK7042-5AF71-1AG0 1FK7060-5AF71-1AG0 1FK7105-5AF71-1AG0
1FK7042-5AF71-1EG0 1FK7060-5AF71-1EG0 1FK7105-5AF71-1EG0
1FK7042-5AF71-1SG0 1FK7060-5AF71-1SG0 1FK7105-5AF71-1SG0
1FK7042-5AF71-1AH0 1FK7060-5AF71-1AH0 1FK7105-5AF71-1AH0
1FK7042-5AF71-1EH0 1FK7060-5AF71-1EH0 1FK7105-5AF71-1EH0
1FK7042-5AF71-1SH0 1FK7060-5AF71-1SH0 1FK7105-5AF71-1SH0
1FK7042-5AF71-1AA0 1FK7060-5AF71-1AA0 1FK7105-5AF71-1AA0
1FK7042-5AF71-1EA0 1FK7060-5AF71-1EA0 1FK7105-5AF71-1EA0
1FK7042-5AF71-1SA0 1FK7060-5AF71-1SA0 1FK7105-5AF71-1SA0
1FK7042-5AF71-1AB0 1FK7060-5AF71-1AB0 1FK7105-5AF71-1AB0
1FK7042-5AF71-1EB0 1FK7060-5AF71-1EB0 1FK7105-5AF71-1EB0
1FK7042-5AF71-1SB0 1FK7060-5AF71-1SB0 1FK7105-5AF71-1SB0
1FK7042-5AF71-1DA0 1FK7060-5AF71-1DA0 1FK7105-5AF71-1DA0
1FK7042-5AF71-1FA0 1FK7060-5AF71-1FA0 1FK7105-5AF71-1FA0
1FK7042-5AF71-1KA0 1FK7060-5AF71-1KA0 1FK7105-5AF71-1KA0
1FK7042-5AF71-1UA0 1FK7060-5AF71-1UA0 1FK7105-5AF71-1UA0
1FK7042-5AF71-1PA0 1FK7060-5AF71-1PA0 1FK7105-5AF71-1PA0
1FK7042-5AF71-1DH0 1FK7060-5AF71-1DH0 1FK7105-5AF71-1DH0
1FK7042-5AF71-1FH0 1FK7060-5AF71-1FH0 1FK7105-5AF71-1FH0
1FK7042-5AF71-1KH0 1FK7060-5AF71-1KH0 1FK7105-5AF71-1KH0
1FK7042-5AF71-1UH0 1FK7060-5AF71-1UH0 1FK7105-5AF71-1UH0
1FK7042-5AF71-1PH0 1FK7060-5AF71-1PH0 1FK7105-5AF71-1PH0
1FK7042-5AF71-1DA5 1FK7060-5AF71-1DA5 1FK7105-5AF71-1DA5
1FK7042-5AF71-1FA5 1FK7060-5AF71-1FA5 1FK7105-5AF71-1FA5
1FK7042-5AF71-1KA5 1FK7060-5AF71-1KA5 1FK7105-5AF71-1KA5
1FK7042-5AF71-1UA5 1FK7060-5AF71-1UA5 1FK7105-5AF71-1UA5
1FK7042-5AF71-1PA5 1FK7060-5AF71-1PA5 1FK7105-5AF71-1PA5
转载请注明出处：上海仰光电子科技专业西门子工控维修
本文链接：http://www.siemens-yg.com/fuwu/2084.htm
